| Recall Date |
OCT 06, 1987 |
| Part Affected |
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY |
| Model Affected |
5000 |
| Units Affected |
25000
Get Details
|
Recall Date
OCT 06, 1987
Model Affected
1986 AUDI 5000
Recall Summary
REPEATED TOPPING OFF OF FUEL TANK DURING REFUELING REDUCES THE EXPANSION SPACE WITHIN THE TANK ALLOWING VAPORS TO ESCAPE FROM THE CHARCOAL FILTER TO OUTSIDE RATHER THAN BEING INDUCTED INTO THE ENGINE.
Defect Consenquence
ESCAPING VAPORS COULD IGNITE BY HEAT EMITTED BY THEEXHAUST SYSTEM.
Remedy
INSTALL REDESIGNED FILLER NECK AND A NEW VENT VALVE AND HOSE FOR CHARCOAL FILTER. ALSO, STOP REFUELING WHEN PUMP NOZZLE SHUTS OFF.
Units Affected
25000
Notes
VOLKSWAGEN OF AMERICA,INC
| Recall Date |
JAN 11, 1993 |
| Part Affected |
POWER TRAIN:AXLE ASSEMBLY |
| Model Affected |
5000 |
| Units Affected |
152000
Get Details
|
Recall Date
JAN 11, 1993
Model Affected
1986 AUDI 5000
Recall Summary
THE DIFFERENTIAL OIL OF THE TRANSAXLE IS LOST OVER TIME DUE TO EVAPORATION. LOW OIL LEVELS CAUSE PREMATURE BEARING AND GEAR WEAR AND EVENTUAL FAILURE OF THE DIFFERENTIAL.
Defect Consenquence
IN THE EVENT OF FAILURE, THE VEHICLE'S DRIVE WHEELS COULDLOSE POWER. IN EXTREME CIRCUMSTANCES, THE FRONT WHEELS LOCK, CAUSING RAPIDDECELERATION RESULTING IN POSSIBLE LOSS OF VEHICLE CONTROL AND AN ACCIDENT.
Remedy
DRAIN AND REPLACE THE DIFFERENTIAL GEAR OIL WITH OIL HAVING HIGHER PERFORMANCE CHARACTERISTICS.
Units Affected
152000
Notes
VOLKSWAGEN OF AMERICA,INC
| Recall Date |
OCT 06, 1987 |
| Part Affected |
SERVICE BRAKES, AIR:DISC:CALIPER |
| Model Affected |
5000 |
| Units Affected |
16000
Get Details
|
Recall Date
OCT 06, 1987
Model Affected
1986 AUDI 5000
Recall Summary
CERTAIN REAR BRAKE CALIPERS COULD BIND AND CONSEQUENTLY OVERHEAT.
Defect Consenquence
OVERHEATED CALIPERS COULD CAUSE BRAKE PEDAL TO FEELSPONGY AND COULD RESULT IN ONE BRAKE CIRCUIT BECOMING INOPERATIVE. BRAKINGABILITY WOULD BE AFFECTED.
Remedy
REQUIRES INSPECTION OF BRAKE CALIPERS AND REPLACEMENT OF CALIPERS AS NECESSARY.
Units Affected
16000
Notes
VOLKSWAGEN OF AMERICA,INC
| Recall Date |
JAN 17, 1989 |
| Part Affected |
FUEL SYSTEM, GASOLINE |
| Model Affected |
5000 |
| Units Affected |
35000
Get Details
|
Recall Date
JAN 17, 1989
Model Affected
1986 AUDI 5000
Recall Summary
FUEL INJECTION SEALS MAY HARDEN, DUE TO HIGH TEMPERATURE AND ALCOHOL IN SOME FUELS, AND ALLOW FUEL TO ESCAPE INTO THE ENGINE COMPARTMENT.
Defect Consenquence
FUEL DRIPPING ONTO HOT ENGINE COMPONENTS COULD CAUSE ANENGINE COMPARTMENT FIRE.
Remedy
REPLACE ENGINES FUEL INJECTOR SEALS WITH IMPROVED SEALS PLUS IMPROVEMENTS DESIGNED TO BETTER INSULATE THE ENGINE AGAINST FIRE RISK.
Units Affected
35000
Notes
VOLKSWAGEN OF AMERICA,INC
| Recall Date |
MAR 04, 1996 |
| Part Affected |
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS |
| Model Affected |
5000 |
| Units Affected |
414
Get Details
|
Recall Date
MAR 04, 1996
Model Affected
1986 AUDI 5000
Recall Summary
THESE BRAKE HOSE ASSEMBLIES HAVE INADEQUATE CRIMPS ATTACHING THE HOSE TO THE HOSE FITTINGS AND COULD CAUSE THE HOSE AND FITTING TO SEPARATE.
Defect Consenquence
IF THE BRAKE HOSE ASSEMBLY SEPARATES, LOSS OF BRAKING POWER CAN OCCUR INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy
THESE BRAKE HOSE ASSEMBLIES WILL BE REPLACED.
Units Affected
414
Notes
EIS BRAKE PARTS
| Recall Date |
JAN 03, 1987 |
| Part Affected |
VEHICLE SPEED CONTROL:CRUISE CONTROL |
| Model Affected |
5000 |
| Units Affected |
81000
Get Details
|
Recall Date
JAN 03, 1987
Model Affected
1986 AUDI 5000
Recall Summary
THE IDLE STABILIZER MAY EXPERIENCE EXCESSIVE WEAR, CAUSING ENGINE IDLE FLUCTUATIONS, USUALLY DESCRIBED AS ENGINE SURGE, WHICH INCREASE WITH USAGE OF THE CAR.
Defect Consenquence
ENGINE SURGE COULD ULTIMATELY SEE-SAW TO THE EXTEND THATLOSS OF VEHICLE CONTROL COULD BE EXPERIENCED IF THE BRAKES WERE NOT APPLIED INTIME. THERE IS A RISK OF A COLLISION AND INJURY IN A CONFINED SPACE.
Remedy
REPLACE IDLE STABILIZATION VALVE.
Units Affected
81000
Notes
VOLKSWAGEN OF AMERICA,INC
| Recall Date |
JAN 03, 1987 |
| Part Affected |
POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:FLOOR SHIFT |
| Model Affected |
5000 |
| Units Affected |
251102
Get Details
|
Recall Date
JAN 03, 1987
Model Affected
1986 AUDI 5000
Recall Summary
SUDDEN ACCELERATION FROM A STATIONARY POSITION MAY OCCUR, WHEN SHIFTING FROM PARK TO REVERSE OR DRIVE.
Defect Consenquence
UNEXPECTED SUDDEN ACCELERATION WITHOUT PRIOR WARNINGCOULD RESULT IN A VEHICLE CRASH, CAUSING INJURIES.
Remedy
INSTALL AN AUTOMATIC SHIFT LOCK TO PREVENT THE TRANSMISSION SHIFT LEVER FROM BEING MOVED FROM PARK TO REVERSE OR DRIVE UNLESS BRAKE PEDAL IS APPLIED AT THE SAME TIME.
Units Affected
251102
Notes
VOLKSWAGEN OF AMERICA,INC
| Recall Date |
AUG 18, 1986 |
| Part Affected |
SEAT BELTS:FRONT:BUCKLE ASSEMBLY |
| Model Affected |
5000 |
| Units Affected |
8000
Get Details
|
Recall Date
AUG 18, 1986
Model Affected
1986 AUDI 5000
Recall Summary
REAR OR FRONT RIGHT SEAT BELT LOCKS MAY NOT PROPERLY ENGAGE. CONSEQUENCE OF DEFECT: SEAT BELTS COULD SEPARATE IN EVENT OF HEAVY BRAKE APPLICATION OR IMPACT AND THUS SUBJECT PASSENGERS TO INJURY.
Defect Consenquence
Remedy
REPLACE SEAT BELTS, AS NECESSARY.
Units Affected
8000
Notes
VOLKSWAGEN OF AMERICA,INC
| Recall Date |
AUG 04, 1986 |
| Part Affected |
FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM |
| Model Affected |
5000 |
| Units Affected |
80710
Get Details
|
Recall Date
AUG 04, 1986
Model Affected
1986 AUDI 5000
Recall Summary
MISADJUSTMENT OF FUEL DISTRIBUTOR ALLOWS FUEL TO ESCAPE AND BE ABSORBED BY THE AIR FILTER. CONSEQUENCE OF DEFECT: WITH THE FUEL ABSORBED BY THE AIR FILTER AND AN ENGINE BACKFIRE ON RESTART, THIS FUEL COULD IGNITE AND RESULT IN AN ENGINE COMPARTMENT FIRE.
Defect Consenquence
Remedy
INSTALLATION OF AN AIR FILTER MODIFICATION KIT TO PRECLUDE FUEL LEAKS.
Units Affected
80710
Notes
VOLKSWAGEN OF AMERICA,INC